Product ID:FLAT ACRYLIC HOUSE PAINT, 1205-SERIES (ALL COLORS)
MSDS Date:08/04/1994
FSC:8010
NIIN:00N075740
MSDS Number: CCWWW

KELLY-MOORE PAINT CO INC

1015 COMMERCIAL ST
SAN CARLOS, CA 94070
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 415-592-8337

Preparer: JULIAN SCHAFER

Cage: 0Y837

KELLY-MOORE PAINT CO INC

SAN CARLOS, CA 94070 US

Telephone: 650-592-8337

Cage: 0Y837

0.1 @ 68F.

CAS: 107-21-1

RTECS: KW2975000

Fraction By Weight: 2.59%

OSHA PEL 50 PPM (MFR)

ACGIH TLV: 50 PPM, VAPOR, C

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

SILICA, CRYSTALLINE - CRISTOBALITE; (SILICA, CRYSTALLINE)

CAS: 14464-46-1

RTECS: VV7325000

Fraction By Weight: 5-25%

OSHA PEL SEE TABLE Z-3

ACGIH TLV: 0.05 MG/M3 RDUST

PROPIONIC ACID, 2-METHYL-, MONOESTER

CAS: 25265-77-4

RTECS: UF6000000

Fraction By Weight: 1-10%

OSHA PEL N/K

ACGIH TLV: N/K

ZINC OXIDE (SARA 313) (CERCLA)

CAS: 1314-13-2

RTECS: ZH4810000

Fraction By Weight: 1-2%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

PIGMENTS SUCH AS INGS 6 - 8. (THESE PIGMENTS CONTAIN ING 9)

RTECS: 9999999ZZ

OSHA PEL N/K

ACGIH TLV: N/K

MINERAL SILICATES

CAS: 1332-58-7

OSHA PEL N/K

ACGIH TLV: N/K

SILICON DIOXIDE

CAS: 14808-57-0

OSHA PEL N/K

ACGIH TLV: N/K

TITANIUM OXIDE; (TITANIUM DIOXIDE)

CAS: 13463-67-7

RTECS: XR2275000

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

SILICA, CRYSTALLINE - QUARTZ; (CRYSTALLINE SILICA)

CAS: 14808-60-7

RTECS: VV7330000

OSHA PEL SEE TABLE Z-3

ACGIH TLV: 0.1 MG/M3 RDUST

PAINT PRESERVATIVES

CAS: 26530-20-1

OSHA PEL N/K

ACGIH TLV: N/K

5-CHLORO-2-METHYL-4-ISOTHIOAZOLIN-3-ONE; (PAINT

CAS: 26172-55-4

RTECS: NX8156850

OSHA PEL N/K

ACGIH TLV: N/K

WITH A DUST FILTER AS NEEDED.

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:DIZZINESS, HEADACHE, NAUSEA,
CONFUSION, IRRITATION TO UPPER RESPIRATORY TRACT, SKIN AND EYE
IRRITATION. CHRONIC:PROLONGED AND/OR REPEATED OVEREXPOSURE TO HIGH
CONCENTRATIONS OF RESPIRABLE (AIRBO RNE) CRYSTALLINE SILICA DUSTS
AS MAY BEGENERATED BY SANDING OR GRINDING OF DRIED PAINTS AND OTHER
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-CRISTOBALITE &
QUARTZ:IARC MONOGRAPHS, SUPP, VOL 7, PG 341, 1987:GRP 2A. NTP 7TH
ANNUAL RPT (SUPDAT)
Effects of Overexposure:HLTH HAZ:BLDG MATLS W/OUT WEARING PROPER NIOSH
APPRVD RESP PROT CAN CAUSE SILICOSIS, A NON-CANCEROUS LUNG DISEASE
THAT CAN RSLT IN SUBSTANTIAL IMPAIRMENT OF BRTHG FUNC. NOTE:THIS
PROD CNTNS PIGMENTS W HICH ARE NOT CONSIDERED HAZ IN WET PAINT BUT
MAY REACH HAZ LEVELS IN DUSTS GENERATED FROM SANDING/GRINDING OF
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE KNOWN. SEE YOUR MD FOR
SPECIFIC MEDICAL OPINION REGARDING YOUR CONDITION.

First Aid:INHAL:REMOVE TO FRESH AIR. RESTORE BREATHING. CONSULT MD.
EYES:FLUSH W/LARGE VOLUMES OF WATER FOR AT LEAST 15 MINUTES. GET
MEDICAL ATTENTION. SKIN:WIPE OFF W/RAG. WASH THOROUGHLY W/SOAP &
WATER. INGES T:CONSULT HOSPITAL EMERGENCY ROOM OR POISON CONTROL
CENTER IMMEDIATELY.

Flash Point:NONE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO THE
BUILD-UP OF STEAM PRESSURE) WHEN EXPOSED TO EXTREME HEAT.

Spill Release Procedures:VENTILATE AREA TO PREVENT BUILD-UP OF VAPORS.
FOR SMALL SPILLS, SOAK UP W/ABSORBANT. FOR LARGER SPILLS, DIKE AREA
W/ABSORBENT MATERIAL & SCOOP UP LIQUIDS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE UPRIGHT IN SEALED CONTAINERS
AWAY FROM HEAT & FLAME.
Other Precautions:PAINT PRESERVATIVES HAVE BEEN ADDED TO CONTROL
SPOILAGE AT LEVELS THAT ARE NOT CONSIDERED HAZARDOUS.

Respiratory Protection:USE NIOSH APPRVD PARTICLE MASK (TC-21C) TO AVOID
BRTHG SPRAY MIST/SANDING DUST IF LOC VENT IS ADEQ TO KEEP VAP CONCS
W/IN ACCEPT (TLV) LIMS. IF LOC VENT IS NOT SUFFICIENT/WHERE EXPOS
LIMS ARE EXCEEDED , WEAR SUITABLE PROPERLY FITTED (SUPDAT)
Ventilation:LOCAL CROSS-VENTILATION OR MECHANICAL EXHAUST SUFFICIENT TO
KEEP ALL HAZARDOUS VAPOR CONCS BELOW PRESCRIBED LIMITS.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:REMOVE & WASH CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
EXPLAN OF CARCIN:ON CARCINS, 1994:ANTIC TO BE CARCIN. EFTS OF
OVEREXP:DRIED PAINT. LIKE MOST NATURALLY OCCURING MINERALS, THESE
PIGMENTS CNTN CRYSTALLINE SILICA WHICH HAS BEEN INCL ON LIST OF
CHEMS "K NOWN BY STATE OF CALIFORNIA TO CAUSE CANCER". RESP
PROT:NIOSH APPRVD RESP (TC-23C OR BETTER) FOR ORGANIC VAPS (ING 12)

Boiling Pt:B.P. Text:212F,100C
Vapor Pres:SEE INGS
Vapor Density:LTR/AIR
Spec Gravity:1.32-1.44
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:55-60

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION AS IN WELDING.

Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . DISCARD IN LAND FILL IN SEALED METAL CONTAINERS AWAY
FROM HEAT & FLAME & I/A/W LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.